Hospital HVAC in Al Manarat

Ventilation needs vary from one department to the next based on the activity in each area and the requirements set by the facility's designer and the site survey. Operating theatres need highly filtered, directionally controlled air, while patient rooms, corridors and administrative areas each carry different requirements. We build the duct network and select units from the facility's drawings and its specific requirements, not from general assumptions.

Yes, but it requires careful planning before the maintenance date. We agree with facility management on a schedule that names the section and the right time window, then isolate the target section using dampers and blanking plates without affecting adjacent departments. Corrective tasks such as replacing a capacitor or repairing a flare joint are carried out within the agreed time window.

Design is governed by the approved facility drawings and each department's requirements as defined by the site survey and the specialist designer. We fabricate ducts in our own workshop from G90 galvanised sheet to project dimensions, and use Kimmco and Armaflex insulation with Foster sealants to control leakage. Distribution and pressure in each section follow the specifications drawn for that department individually.

Design is governed by the approved facility drawings and each department's requirements as defined by the site survey and the specialist designer. We fabricate ducts in our own workshop from G90 galvanised sheet to project dimensions, and use Kimmco and Armaflex insulation with Foster sealants to control leakage. Distribution and pressure in each section follow the specifications drawn for that department individually.

We work with medical facilities of all sizes, from a clinic in a residential district to a multi-storey medical complex. The size of the facility does not change the principle: the site survey is the starting point, and from it we determine unit types, duct dimensions and fresh-air requirements for each zone. Preventive and corrective maintenance contracts are available for clinics and hospitals alike.

An operating theatre needs positive pressure (air flows out) to prevent external contaminants entering, whilst an isolation ward needs negative pressure (air enters but does not leave) to contain any viruses or bacteria inside. Our system controls each independently.

Yes, we schedule routine maintenance during lower-activity periods and work in close coordination with the hospital's maintenance teams. For any emergency, we have temporary backup equipment ready to deploy quickly to keep medical operations running.

We install outdoor units with wind-resistant fixings and choose protected roof or ground locations where possible. We inspect fixings and connections regularly as strong winds and sea salt accelerate corrosion.

Yes, long ducts reduce air distribution efficiency, so we use stronger compressors and fit pressure compensators at key points. We regularly check airflow and pressure across all departments to ensure each receives the air and control it needs.